GCRTA may unify its rail system with single rail car fleet

The Greater Cleveland Transit Authority has operated two types
of rail cars since 1955 (light-rail at left, heavy-rail at right). But
the authority is reconsidering that dual system as faces replacing
its aging rail cars with new ones that can fit into its Central Rail
maintenance facility near East 55th Street, shown above (KJP).
CLICK IMAGES TO ENLARGE THEM

For those who like the idea of being able to take one train without transfers from Shaker Heights to the airport or possibly from University Circle to the Van Aken District, then a new challenge-turned-opportunity may be of interest.

The Greater Cleveland Regional Transit Authority (GCRTA) may replace its two aging rail fleets with a single type of rail car that can operate on any of GCRTA’s three rail lines. This is big news because GCRTA had been considering replacing its two old, yet separate rail fleets with two new and still-separate rail fleets, continuing an inefficient practice set into motion nearly 80 years ago.

A single, interoperable rail fleet also raises some intriguing possibilities if GCRTA ever gets into expansion mode again. More on that later. Those future possibilities, not just the efficiency aspects, are why a single rail fleet has been urged by advocacy groups like All Aboard Ohio for many years.

Currently, GCRTA uses two types of rail cars that are interoperable on only three miles of Greater Cleveland’s 39-mile rail system. One is a fleet of light-rail vehicles (LRV) made by the Breda Co. in 1980-81. These 34 cars operate on the Blue and Green lines between the downtown Waterfront and Shaker Heights. The first segments of this LRV system were built in 1913, modernized in the 1980s and expanded in 1996.

The other is a fleet of heavy-rail vehicles (HRV) made by Tokyu in 1984-85. These 40 cars operate on the Red Line between Hopkins International Airport, downtown Cleveland and Windermere in East Cleveland. This HRV route was first planned in the 1940s and opened in 1955.

GCRTA’s Red Line is operated by heavy-rail vehicles that serve
high-level station platforms that are at the same height as the
floors on the trains to ensure access by disabled riders (AAO).

The two rail fleets are inoperable on their different rail lines because of the types of rail stations they must serve. The HRVs serve high-level station platforms. The LRVs serve low-level platforms. On the three route-miles that the HRVs and LRVs are interoperable, there are three stations with both high-level and low-level platforms.

All of GCRTA’s 52 rail stations and trains must be compliant with federal ADA standards which includes having station platform floors at or near the same level as the rail cars’ floors. This is called level boarding, requiring a vertical gap of no more than two inches. There must also be a minimal horizontal gap separating the train and platform that does not exceed four inches.

All Red Line stations are ADA-compliant as are the busier Blue/Green stations (e.g.:?Green Road, Warrensville on both lines, Lee Road on both lines, Farnsleigh, Shaker Square, East 55th and all of the other Blue/Green line stations farther into the city). Nearly two dozen Blue/Green stations are not yet ADA-compliant.

To rebuild all 52 stations to serve both high- and low-floor HRVs and LRVs and be ADA-compliant would cost hundreds of millions of dollars. Merely modifying just the 19 high-platform Red Line stations so they could accommodate a single type of rail car might cost $10+ million.

GCRTA’s rail car replacement consultant, LTK Engineering, said modifying the stations would negate any cost savings from having an interoperable rail fleet with standardized replacement parts, standardized training, etc. LTK and GCRTA proposed to acquire 34 new HRVs costing $3 million each and 24 new LRVs at $4 million each.

But as GCRTA and LTK representatives talked to rail car manufacturers to replace the HRVs (which LTK says the Tokyu-built cars are decaying more quickly than the Breda-built LRVs), GCRTA discovered a new challenge. HRV manufacturers today are building train cars that come in what’s called “married pairs.”

A light-rail vehicle on the Blue Line departs the Farnsleigh
station for the end of the line at Warrensville, site of the new
Van Aken District transit-oriented development. Heavy-rail
trains with high floors and no stairs cannot serve this line
or the Green Line because the stations have low-level
platforms, tight curves and tight clearances (AAO).

In other words, each HRV is really two shorter cars but semi-permanently connected to each other. To disconnect them requires partially disassembling them — a costly and time-consuming process needed each time one of dozens of rail cars goes in for inspections or maintenance. Together, the married pairs are longer than GCRTA trains and their entire Central Rail Maintenance Facility near East 55th Street, built in the early 1980s, was designed around GCRTA’s rail fleets.

Today’s married pair HRVs are too long for GCRTA’s maintenance facility, especially a highly useful and efficient transfer table that moves trains around to different work tracks inside Central Rail. Modifying Central Rail to accommodate married-pair HRVs could cost tens of millions of dollars — potentially more than the cost of modifying GCRTA’s rail stations. Modern LRVs are shorter than contemporary HRVs.

Furthermore, any investment to modify the stations and allow the same trains to travel anywhere in the GCRTA rail system, directly benefitting transit riders. In contrast, any maintenance facility modifications won’t be personally seen by riders and thus can’t offer the kinds of direct benefits that enhance the transit-riding experience.

Michael Schipper, GCRTA’s deputy general manager of engineering & project management, said staff will prepare a briefing to the GCRTA board in late summer before it issues a request for proposals this fall to rail car manufacturers.

In it, staff will reportedly include an option of either acquiring HRVs and modifying Central Rail which could reduce its availability to the entire rail system for months. Or it could include acquiring standardized LRVs and modifying Red Line stations which could remove from service each half (west and east halves) of the line for weeks at a time.

Reequipping the rail fleet with trains that can use any rail line,
including future ones, increases the destination possibilities
and thus increases the value of land around rail stations
for transit-oriented development such as this which
now surrounds the 2015-built Little Italy-Univer-
sity Circle Red Line station (KJP).

The reason why the Red Line HRV stations would have to be modified and not the Blue/Green Line LRV stations is because the HRVs are nine inches wider than the LRVs and their floors are 14 inches higher than those in the tallest LRVs. It would be far more costly and disruptive to modify the Blue/Green Line stations. And, besides, the HRVs are decaying faster and must be replaced in five years or less, LTK says.

That means extending the trackside edge of each Red Line station platform by about 4.5 inches and raising the tracks through each Red Line station by 14 inches. At most stations, raising tracks involves a relatively simple and inexpensive addition of more ballast (a type of gravel) and tamping it (ie: tucking) it under the track at each station.

That gets a little more complicated at the four stations (West 117th, Cedar-University, Little Italy-University Circle and Superior) that are on or right next to bridges above streets. And it gets a lot complicated at the Airport station where the tracks are attached to concrete slabs. GCRTA may also want to modify Tower City station (its tracks are also attached to concrete slabs) to use platforms at the same height as the trains’ floors to expedite the loading and unloading of large crowds.

Replacing the entire rail fleet and making modifications to Red Line stations or to Central Rail will cost upwards of $240 million. GCRTA has $118 million committed thus far which is near to what GCRTA needs for placing an order for the new HRVs, Schipper said.

Benefits to GCRTA riders from a standardized fleet of rail cars could someday go beyond running Green Line trains from Green Road in Shaker Heights through to Hopkins Airport without an en route transfer.

Consider if GCRTA extended the under-used Waterfront Line around the east side of downtown, next to Playhouse Square, through Cleveland State University, St. Vincent Charity Hospital, Cuyahoga Community College and back to the Red/Blue/Green lines near the East 34th Street station.

These were the final, recommended options
for extending the light-rail Waterfront Line
around downtown Cleveland, creating a
loop around the central business district.
This would become even more useful if
GCRTA used a standardized rail fleet
so that trains from all of the rail lines
could use the loop (GCRTA).

It could also help promote the development of the northeast side of downtown above the lakefront bluffs, now just a collection of parking lots and low-scale commercial buildings. A tax-increment financing district along the rail corridor could help provide a non-federal construction share and/or help sustain the downtown rail loop’s operations. And best of all, trains from the Red, Blue and Green lines could all serve the downtown loop in clockwise and/or counter-clockwise directions.

One of the biggest shortcomings of GCRTA’s rail system is that it has only one dominant downtown station. Tower City is located on the western side of downtown. A downtown rail loop, as GCRTA proposed in 2000 and found feasible enough that it would warrant federal funding, would put all of downtown Cleveland within a 10-minute walk of a rail transit station.

Another shortcoming of the GCRTA rail system is that it doesn’t extend outward far enough. Rail extensions to Euclid and to Highland Hills/I-271 were recently studied and found to be promising (the Highland Hills extension was studied before the Van Aken District, Pinecrest and other developments were built). But GCRTA lacks the local and state funding to attract the necessary federal dollars.

Both of those extensions were assumed to involve trains operating to downtown and back only. But with a standardized rail fleet, LRVs could also operate between Highland Hills and Euclid via University Circle which is where many commuters from the eastern suburbs are bound.

More destinations make development around existing rail stations more attractive. And there are already increasing amount of station-area developments occurring downtown, in University Circle, Little Italy, Ohio City, Detroit-Shoreway, Shaker Heights and elsewhere.

These examples show not only the kind of operational flexibility that a single type of LRV fleet for the entire GCRTA rail system offers, but how it could foster greater access to jobs, station-area housing and economic development for Greater Cleveland.

END

Scroll to Top